* Corresponding Author
Reduction of NOx Emission from Gas TURBINE COMBUSTOR Applying Fuel-Staged Combustion
https://doi.org/10.22146/ajche.50804 Mohammad Nazri(1*), Mohd. Jaafar(2)
(1) Department of Aeronautics and Automotive, Mechanical Engineering Faculty Universiti Teknologi Malaysia, 81310 UTM Skudai, JOHOR, Malaysia Fax: 607-5566159
(2) Department of Aeronautics and Automotive, Mechanical Engineering Faculty Universiti Teknologi Malaysia, 81310 UTM Skudai, JOHOR, Malaysia Fax: 607-5566159
(*) Corresponding Author
Abstract
A two-stage lean/lean gas turbine combustor was developed with low NOx characteristics in each stage using a small radial swirler of 40-mm outlet diameter in the pilot stage. Both flame tubes were arranged in series with the smaller combustor (76 mm inside diameter) as the pilot stage and the larger combustor (140 mm inside diameter) as the main stage. The pilot stage was fuelled via vane passage fuel injector, while the main stage was fuelled around the wall of the exit plane of the pilot stage, using wall fuel injectors. Low NOx emissions were obtained when using fuel staging for methane fuel, as low as 6 ppm. A NO. reduction of more than 40 % was obtained at equivalence ratio of near 0.7, when using fuel staging compared to the non-fuel-staging test. Tests were conducted using methane as fuel. This was achieved at very small increase in carbon monoxide emissions especially near the rich region and with almost no increase at all in the unburned hydrocarbon emissions at the same equivalence ratio.
Keywords: NOx emissions, fuel staging, carbon monoxide, swirler.
Keywords: NOx emissions, fuel staging, carbon monoxide, swirler.
Keywords
NOx emissions, fuel staging, carbon monoxide, swirler.
Full Text:
PDFReferences
- Harrison, R.M.; "Important Air Pollutants and Their Chemical Analysis. Pollution: Causes, Effects and Control", Royal Society of Chemistry, London, 1990, Chapter 8, pp 156-175.
- World Health Organisation, "Air Quality Guidelines for Europe", WHO Regional Publications, European Series No. 23, ISBN 92 890 1114 9. WHO Regional Office for Europe: Copenhagen, 1987.
- Van Der Meij,C.E. et al.; "On the Effects of Fuel Leakage on CO Production From Household Burners as Revealed by LIF and CARS", Twenty fifth Symposium (International) on Combustion, The Combustion Institute, 1994, pp 243-250.
- Shaw, H., "The Effects of Water,Pressure, and Equivalence Ratio on Nitric Oxide Production in Gas Turbines" , Transactions of the ASME, Journal of Engineeringfor Gas Turbinesand Power, pp. 240-246, July 1974.
- Sarofim, A.F. and Flagan, C., "NO" Control for Stationary Combustion Sources", Prog. Energy Combustion Science, Vol. 2, pp. 1-25, Pergamon Press, 1976.
- Correa, S.M., "AReview of NO"FormationUnder Gas-Turbine Combustion Conditions", Combust. Sci. and Tech.,Vol.87, pp. 329- 362,1992.
- Lefebvre,A.H.; "PollutionControl inContinuous Combustion Engines" , Fifteenth Symposium (International) on Combustion, The Combustion Institute, 1975, pp 1169-1180.
DOI: https://doi.org/10.22146/ajche.50804
Article Metrics
Abstract views : 3575
| 
views : 2312
Refbacks
- There are currently no refbacks.