Gas-Liquid Mass Transfer in Continuous Oscillatory Flow Baffled Columni

  • Taslim Taslim Department of Chemical and Process Engineering, University Kebangsaan Malaysia
  • Mohd Sobri Takriff Department of Chemical and Process Engineering, University Kebangsaan Malaysia
Keywords: Baffle columns, fluid oscillation, liquid-side volumetric mass transfer coefficient (k, a), mass transfer improvement, power consumption, superficial gas-liquid velocity

Abstract

Gas-liquid mass transfer in continuous oscillatory flow was conducted in a vertical baffled column. Pure carbon dioxide (C02) was used as the dispersed phase and tap water was used as the continuous phase. The mass transfer rate of C02 measured under continuous operation was expressed in terms of the liquid-side volumetric mass transfer coefficient (kLa) and was calculated using a stationary method. The effects of oscillation frequency, oscillation amplitude, and flow rates on mass transfer were also determined. The results showed that a significant increase in mass transfer could be achieved in oscillatory flow in a baffled column comp.:lfed to that in a bubble column. The mass transfer in continuous oscillatory flow in a baffled column was not affected by the liquid flow rate in the range tested. Then, kLQwas correlated as a function of power density and superficial gas velocity.

References

Baird, M. H. I., and Stonestreet, P. (1995). “Energy dissipation in oscillatory flow within a baffled tube," Trans IChemE., 73, 503-11.
Brunold, C. R., Hunn, J. C. B., Mackley, M. R., and Thomson, J. W. (1989). "Experimental observations on flow patterns and energy losses for oscillatory flow in ducts containing sharp edges," Chem. Eng. Sci., 44, 1227-44.
Butler, J. M. (1982). Carbon dioxide equilibria and their applications, Addison-Wesley, London. 15-20.
Dickens, A, W., Mackley, M. R., and William, H. R. (1989). “Experimental residence time distribution measurements for unsteady flow in baffled tubes," Chem. Eng. Sci., 44, 1471-79.
Hewgill, M. R., Mackley, M. R., Pandit, A. B., and Pannu, S. S. (1993). “Enhancement of gas-liquid mass transfer using oscillatory flow in baffled tubes," Chem. Eng. Sci., 48, 799-803.
Jealous, A.C., and Johnson, H. F. (1995). "Power requirements for pulse generation in pulse column," Ind. Eng. Chem., 47, 1159–66.
Kojima, H., Uchida, Y., Ohsawa, T., and lguci, A. (1987). “Volumetric liquid-phase mass transfer coefficient in gas-sparged three phase stirred vessel," J. Chem. Eng. Japan, 20, 104-6.
Mackay, M. E., Mackley, M. R., and Wang, Y. (1991). "Oscillatory flow within tubes containing wall or central baffles," Trans IChemE., 71, 649-56.
Mackley, M. R. (1987 February). "Using oscillatory flow to improve performance," Chem. Eng., 18-20
Mackley, M. R. (1991). “Process innovation using oscillatory flow within baffled tubes," Trans IChemE., 69, 197-99.
Ni, X., Gao, S., and Pritchard, D. W. (1995). "Study of mass transfer in yeast in a pulsed baffled bioreactor," Biotechnol. and Bioeng., 45, 165–75.
Ni, X., and Gough, P. (1997). "On the discussion of dimensionless groups governing Oscillatory flow in a baffled tube," Chem. Eng. Sci., 52, 3209-12.
Published
2004-12-31
How to Cite
Taslim, T., & Takriff, M. S. (2004). Gas-Liquid Mass Transfer in Continuous Oscillatory Flow Baffled Columni. ASEAN Journal of Chemical Engineering, 4(2), 1-6. Retrieved from https://journal.ugm.ac.id/v3/AJChE/article/view/7592
Issue
Vol 4 No 2 (2004)
Section
Articles

Copyright holder for articles is ASEAN Journal of Chemical Engineering. Articles published in ASEAN J. Chem. Eng. are distributed under a Creative Commons Attribution-NonCommercial 4.0 International (CC BY-NC 4.0) license. 

Authors agree to transfer all copyright rights in and to the above work to the ASEAN Journal of Chemical Engineering Editorial Board so that the Editorial Board shall have the right to publish the work for non-profit use in any media or form. In return, authors retain: (1) all proprietary rights other than copyright; (2) re-use of all or part of the above paper in their other work; (3) right to reproduce or authorize others to reproduce the above paper for authors’ personal use or for company use if the source and the journal copyright notice is indicated, and if the reproduction is not made for the purpose of sale.