CO Digestion for Biogas Production from Tapioca Industrial Wastewater and Septage

https://doi.org/10.22146/ajche.49544

Agus Hadiyarto(1*), Danny Soetrisnanto(2), Asep Muhammad Samsudin(3), Prinanda De Aqila Asri(4), Said Abdillah(5)

(1) Chemical Engineering Department Diponegoro University
(2) Chemical Engineering Department Diponegoro University
(3) Chemical Engineering Department Diponegoro University
(4) Chemical Engineering Department Diponegoro University
(5) Chemical Engineering Department Diponegoro University
(*) Corresponding Author

Abstract


In this study, a combination of substrate rich carbon with substrate rich nitrogen was carried out. The experiments were conducted in batches process by varying the C/N ratio and types of anaerobic microbial sludge of the cow rumen, anaerobic microbial sludgefrom wastewater treatment plant (WWTP) of septage and anaerobic sludge from WWTP of tapioca industry. Practically in the range of C/N ratio 20-30 didn’t give a significant effect on the biogas production.The C/N 30 ratio provides the most biogas production rate, while the microbe derived from the cow rumen gives the most biogas production rate.Adaptation phase occurred up to 11th days, growth phase occurred lasted until day 24st, stationary phase occurred in the range of day 24th-31st and death phase occurred after day 31st. Biogas yield (by cow rumen) is 1,127 liters per kg of COD removed or 161 liters per kg of COD per day.

Keywords


biogas, co digestion, C/N ratio, septage, tapioca wastewater, cow rumen

Full Text:

PDF


References

  1. BSNI, (1991). Analize of Suspended Solid (SNI 06-2413-1991). National Standardization Agency of IndonesiaJakarta
  2. BSNI, (2004a). Analize of CODCr (SNI 06-6989.15-2004). National Standardization Agency of Indonesia Jakarta
  3. BSNI, (2004b). Analize of Total Kjeldhal Nitrogen (SNI 19-7030-2004). National Standardization Agency of Indonesia Jakarta
  4. BSNI, (2006). Total Organic Carbon-SNI 01-3554-2006, National Standardization Agency of Indonesia Jakarta
  5. Deublein D, Steinhauser (2008) A. Biogas from waste and renewable Resource : An Introduction. Wiley-VCH Verlag GmbH & Co. KGaA. Weinheim
  6. Erfin,Y. Et al., 2012. Studi Pemanfaatan Feses (Kotoran Manusia) sebagai Bahan Baku Alternatif Energi Terbarukan. Jurnal Ilmu Pengetahuan dan Teknologi, Serpong Tangerang.
  7. Fettig J, Pick V, Austermann-Haun U, Blumberg M, Phuoc NV.(2013) Treatment of tapioca starch wastewater by a novel combination of physical and biological processes.Water Sci Technol.68(6):1264-70. doi: 10.2166/wst.2013.354
  8. Guerrero L, Omil F, Mondes R, Lema J.M.(1997). Treatement of saline wastewater from fish meal factories in an anaerobic filter under extreme ammonia concentrations. Bioresource Technol. 61(1): 69-78
  9. Grady,Jr., C.P.L dan H.C Lim, 1980, Biological Wastewater Treatment, Theory and Application, Marcel Dekker Inc, New York.
  10. Gerardi, M.H., 2003. The Microbiology of Anaerobic Digesters,
  11. Kayhanian M. (1994) Ammonia inhibition in high solid biogasification : anoverview and practical solution.Environ.Technol. 20 : 355-365
  12. Robby, R. et al., 2013. Produksi Biogas dari Limbah Cair Industri Tepung Tapioka dengan Raektor Anaerobik 3.000 Liter Berdistributor. Jurnal Teknik POMITS. Institut Teknologi Sepuluh November, Yogyakarta.
  13. Seadi, T. A ed., 2008. Biogas Handbook T. , Denmark: University of Southern Denmark Esbjerg, Niels Bohr Vej 9-10.
  14. Zeshan OP, Karthikeyan (2012) .Effect of C/N ratio and ammonia-N accumulation in pilot scale thermophilic dry anaerobic digester . Bioresource Technol. 113 (0): 294-302



DOI: https://doi.org/10.22146/ajche.49544

Article Metrics

Abstract views : 1367 | views : 1205

Refbacks

  • There are currently no refbacks.


ASEAN Journal of Chemical Engineering  (print ISSN 1655-4418; online ISSN 2655-5409) is published by Chemical Engineering Department, Faculty of Engineering, Universitas Gadjah Mada.