* Corresponding Author
Karakteristik Pengeringan Jamur Tiram (Pleurotus ostreatus var. florida) Menggunakan Pengering Tipe Fluidized Bed Drier
https://doi.org/10.22146/agritech.10619 Tjahja Muhandri(1*), Sarah Diana Yulianti(2), Elis Nina Herliyana(3)
(1) Departemen Ilmu dan Teknologi Pangan, Institut Pertanian Bogor, Kampus IPB Darmaga, PO BOX 220 Bogor 16002
(2) Departemen Ilmu dan Teknologi Pangan, Institut Pertanian Bogor, Kampus IPB Darmaga, PO BOX 220 Bogor 16002
(3) Departemen Silvikultur, Institut Pertanian Bogor, Jl. Lingkar Akademik Kampus IPB Darmaga, Bogor 16680
(*) Corresponding Author
Abstract
The current practice for improving the quality and for ease handling of the oyster mushroom is drying. The drawback of this process results in dark color of the mushroom once it is dried. This color quality reduction wascaused by an unappropriate handling before drying and an over process of the drying. Thus, the objective of the research was to determine the most suitable model for drying rate of the mushroom and the best pre-treatments before drying. In this research, the influence of six pre-treatments before drying (1) control/without any pre-treatment, (2) washed using water, (3) blanching, (4) blanching followed by immersion in sodium metabisulphite solution, (5) blanching using a sodium metabisulphite solution, and (6) soaking in sodium metabisulphite solution, followed by blanching, on the quality of the mushroom (rehydration behavior) was elucidated. Those six samples were subjected to drying process using fluidized bed drier at 60 °C with airflow rate between 0.619 and 0.839 m/s until the samples reached equilibrium moisture content. The equilibrium moisture content was achieved after drying process of the mushroom from 270 to 330 minutes. Results indicated that Lewis model more suitable than Page model for prediction of the mushroom drying rate. Results also showed that the control/without any pre-treatment before drying and sample with washed using water were the best pre-treatments before drying resulted in the highest rehydration ratio with the short time of 150 minutes to reach the moisture content of 12%.
ABSTRAK
Proses pengeringan jamur tiram (Pleurotus ostreatus) dilakukan untuk meningkatkan mutu dari jamur tiram dan mempermudah penanganannya. Penurunan mutu yang terjadi ketika jamur tiram dikeringkan adalah warna jamur yang coklat gelap dan tidak disukai konsumen. Kondisi ini terjadi karena penanganan sebelum pengeringan yang tidak tepat serta proses pengeringan yang terlalu lama. Penelitian ini dilakukan untuk mengetahui persamaan laju pengeringan jamur tiram, prediksi waktu pengeringan dan perilaku rehidrasinya. Jamur tiram diberi enam perlakuan yang berbeda yaitu (1) kontrol, (2) dicuci air bersih, (3) blansir, (4) blansir yang dilanjutkan dengan perendaman dalam natrium metabisulfit, (5) blansir dalam larutan natrium metabisulfit, dan (6) perendaman dalam larutan natrium metabisulfit yang dilanjutkan dengan blansir. Pengeringan dilakukan dengan fluidized bed dryer pada suhu 60 °C dan kecepatan udara pengering yang berada pada kisaran 0,619 m/detik hingga 0,839 m/detik sampai sampel mencapai kadar air kesetimbangan. Kadar air kesetimbangan (moisture equilibrium) dicapai setelah pengeringan selama 270 - 330 menit. Hasil pengujian menunjukkan bahwa model Lewis lebih sesuai dibandingkan dengan model Page untuk memprediksi laju pengeringan jamur tiram. Sampel jamur tiram tanpa perlakuan dan jamur tiram dengan perlakuan pencucian tanpa blansir merupakan sampel terbaik dengan waktu untuk mengeringkan hingga mencapai kadar air 12% adalah 150 menit dan rasio rehidrasi yang lebih tinggi dibandingkan sampel lainnya.
Keywords
Full Text:
PDFReferences
Alam, N., Amin, R., Khan, A., Ara, I., Shim, M.J., Lee, M.W. dan Lee, T.S. (2008). Nutritional analysis of cultivated mushroom in Bangladesh-Pleurotus ostreatus, Pleurotus sajor-caju, Pleurotus florida and Calocybe indica. The Korean Society of Mycology 36(4): 228–232.
Arora, S., Shivhare, U.S., Ahmed, J. dan Raghavan, G.S.V. (2011). Drying kinetics of Agaricus bisporus and Pleurotus florida mushroom. American Society of Agricultural Engineers 46(3): 721-724.
AOAC. (1995). Official Method of Analysis of the Association of Official Agricultural Chemist 16th Edition. AOAC International, Virginia.
Belloso, M.B. dan Fortuny, R.S. (2010). Advances in Fresh-Cut Fruits and Vegetables Processing. Boca Raton: CRC Press.
Bhattacharya, M., Srivastav, P.P. dan Mishra, H.N. (2014). Optimization of microwave-convective drying of oyster mushrooms (Pleurotus ostreatus) using respose-surface methodology. International Food Research Journal 21(4): 1575–1581.
CODEX Alimentarius Commision (1981). Codex Standard for Dried Edible Fungi CODEX STAN 39-1981.
Doymaz, I. (2014). Drying kinetics and rehydration characteristics of convective hot-air dried white button mushroom slices. Journal of Chemistry. 2014:1-8. Doi: dx.doi.org/10.1155/2014/453175.
Erbay, Z. dan Icier, F. (2010). A review of thin layer drying of foods: theory, modeling, and experimental result. Critical Review in Food Science and Nutrition 50: 441–464. Doi: 10.1080/10408390802437063.
FDA (Food and Drugs Administrations) (2013). Annex J: Summary of Current Food Standars. http://www.fda.gov.ph/attachments/article/71149/Annex%20J%20-%20FOOD%20STANDARDS.pdf. [2 Januari 2016].
Ghaderi, A., Abbasi, S., Motevali, A. dan Minaei, S. (2012). Comparison of mathematical models and atificial neural networks for prediction of drying kinetics of mushroom in microwave-vacuum drier. Chemical Industry and Chamical Engineering Quarterly 18(2): 283–293.
Giri, S.K. dan Prasad, S. (2007). Drying kinetics and rehydration characteristics of microwave-vacuum and convective hot-air dried mushrooms. Journal of Food Engineering 78 (2): 512–521. Doi:10.1016/j/jfoodeng.2005.10.021.
Guiné, R.P.F. dan Barocca, M.J. (2011). Influence of freeze-drying treatment on the texture of mushrooms and onions. Croatia Journal of Food Science and Technology 3(2): 26–31.
Hassan, F.R.H. dan Medany, G.M. (2014). Effect of pretreatments and drying temperatures on the quality of dried Pleurotus mushroom spp. Egyptian Journal of Agricultural Research 92 (3): 1009–1023.
Jambrak, A.R., Mason T.J., Paniwnyk, L. dan Lelas, V. (2007). Accelerated drying of button mushrooms, Brussels sprouts and cauliflower by applying power ultrasound and its rehydration properties. Journal of Food Engineering 81: 88–97.
Kotwaliwale, N., Bakane, P. dan Verma, A. (2007). Changes in textural and optical properties of oyster mushroom during hot air drying. Journal of Food Engineering 78: 1207–1211.
Kulshreshtha, M., Singh, A. dan Deepti, V. (2009). Effect of drying conditions on mushroom quality. Journal of Engineering Science and Technology 4(1): 90–98.
Marabi, A. dan Saguy, I.S. 2009. Rehydration and reconstitution of food. Di dalam: Ratti C, editor. Advance in Food Dehydration. Boca Raton (US): CRC Press.
Patil, S.S., Ahmed, S.A., Telang, A.M. dan Baig, M.M.V. (2010). The nutritional value of pleurotus ostreatus (Jacq.: FR) kumm cultivated on different lignocellulostic agro-wastes. Innovative Romanian Food Biotechnology 7: 66–76.
Quevedo, R., Ronceros, B., Garcia, K., Lopez, P. dan Pedreschi, F. (2011). Enzymatic browning in sliced and pureed avocado: a fractal kinetic study. Journal of Food Engineering 105(2): 210–215.
Quevedo, R., Pedreschi, F., Bastias, J.M. dan Diaz, O. (2016). Correlation of the fractal enzymatic browning rate with the temperature in mushroom, pear, and apple Slices. LWT – Food Science and Technology 65: 406–413.
Vullioud, M.B., Rusalen, R. dan De Michelis, A. (2011). Blanching process of oyster mushrooms (Pleurotus ostreatus) and its effects on parameters of technological interest in Argentina. Micologia Aplicada International 23 (2): 47–53.
Walde, S.G., Velu, V., Jyothirmayi, T. dan Math, R.G. (2006). Effects of pretreatment and drying methods on dehydration of mushroom. Journal of Food Engineering 74: 108–115.
DOI: https://doi.org/10.22146/agritech.10619
Article Metrics
Abstract views : 3760
| 
views : 4533
Refbacks
- There are currently no refbacks.
Copyright (c) 2017 Tjahja Muhandri, Sarah Diana Yulianti, Elis Nina Herliyana
This work is licensed under a Creative Commons Attribution-ShareAlike 4.0 International License.
agriTECH has been Indexed by:
agriTECH (print ISSN 0216-0455; online ISSN 2527-3825) is published by Faculty of Agricultural Technology, Universitas Gadjah Mada in colaboration with Indonesian Association of Food Technologies.