* Corresponding Author
Skrining Lactobacillus plantarum Penghasil Asam Laktat untuk Fermentasi Mocaf
https://doi.org/10.22146/agritech.18821 Zulafa Noor(1*), Muhammad Nur Cahyanto(2), Retno Indrati(3), Sardjono Sardjono(4)
(1) Sekolah Tinggi Teknologi Nasional, Jl. Babarsari Caturtunggal, Depok, Sleman, Yogyakarta 55281
(2) Departemen Teknologi Pangan dan Hasil Pertanian, Fakultas Teknologi Pertanian, Universitas Gadjah Mada, Jl. Flora No. 1, Bulaksumur, Yogyakarta 55281
(3) Departemen Teknologi Pangan dan Hasil Pertanian, Fakultas Teknologi Pertanian, Universitas Gadjah Mada, Jl. Flora No. 1, Bulaksumur, Yogyakarta 55281
(4) Departemen Teknologi Pangan dan Hasil Pertanian, Fakultas Teknologi Pertanian, Universitas Gadjah Mada, Jl. Flora No. 1, Bulaksumur, Yogyakarta 55281
(*) Corresponding Author
Abstract
This study was aimed to select the best isolates of Lactobacillus plantarum from 6 (six) of local isolates obtained from culture collections isolated from traditional foods. Selection of isolates was based on the growth rate, the number of cells, changes in pH and lactic acid production during cell growth on the MRS-broth at 37 °C for 24 hours. The results showed that the growth rate of each isolate varied, as measured by the length of the log phase, ranging from 8-20 h. It showed that some isolates quite fast towards a stationary phase and some quite slow. The number of cell ranged from 8.81 to 9.74 log CFU/mL, while the pH at the beginning of cell growth from 5.2 to 5.8, and at the end of growth from 3.4 to 3.7. Lactic acid production by the end of the growth (24 h) is 0.76 to 0.98%. The results showed isolate of L. plantarum UA3 was best having the fastest growth rate (8 h of log phase), the highest cell number (9.74 log CFU/mL), and the highest lactic acid produced (0.92 %) for 14 h incubation on MRS-broth at 37 °C. Application of selected isolate of L. plantarum UA3 on solid substrate fermentation using media grated cassava yield in 0.92% lactic acid after fermentation for 60 h, with a cell number of 9.54 log CFU/mL.
ABSTRAK
Penelitian ini bertujuan untuk memilih isolat Lactobacillus plantarum terbaik dari 6 (enam) macam isolat lokal yang diperoleh dari koleksi kultur yang berasal dari makanan tradisional. Pemilihan isolat didasarkan pada kecepatan pertumbuhan, jumlah sel, perubahan pH dan produksi asam laktat selama pertumbuhan pada media MRS-broth pada suhu 37 °C selama 24 jam. Hasil penelitian menunjukkan bahwa kecepatan pertumbuhan setiap isolat bervariasi, yang diukur dari lamanya fase log, yaitu berkisar antara 8–20 jam. Ini memperlihatkan bahwa beberapa isolat cukup cepat menuju fase stasioner dan beberapa lagi cukup lambat. Jumlah sel berkisar antara 8,81–9,74 log CFU/mL, sedangkan pH pada awal pertumbuhan sekitar 5,2–5,8, dan pada akhir pertumbuhan 3,4–3,7. Produksi asam laktat pada akhir pertumbuhan (24 jam) adalah 0,76–0,98%. Dari hasil tersebut isolat L. plantarum UA3 merupakan isolat terbaik dengan fase pertumbuhan log yang tercepat (8 jam), jumlah sel tertinggi (9,74 log CFU/mL), dan menghasilkan asam laktat paling tinggi (0,92%) pada inkubasi selama 14 jam dalam media MRS-broth suhu 37 °C. Aplikasi dari isolat terpilih L.plantarum UA3 dalam fermentasi substrat padat menggunakan media kasava parut menghasilkan asam laktat sebesar 0,92% setelah fermentasi selama 60 jam, dengan jumlah sel 9,54 logCFU/mL.
Keywords
Full Text:
PDFReferences
Anike N. dan Okafor, N. (2008). Secretion of methionine by microorganism assosiated with cassava fermentation. African Journal of Food, Agriculture, Nutrition and Development 8: 77–90.
Anonim (1995). Bacterial Analytical Manual 8th Ed. AOAC International. Gaitherburg.
Arisanti, D. (2012). Viabilitas Bakteri Asam Laktat Selama Penyiapan dan Penyimpanan Ragi Mocaf serta Aplikasinya pada Fermentasi Ubi Kayu Segar. Tesis. Fakultas Teknologi Pertanian. Universitas Gadjah Mada, Yogyakarta.
Brashears, M.M. dan Carminati D. (2010). Survival during frozen and subsequent refrigerated storage of Lactobacillus acidophillus cells as influenced by the growth phase. Journal of Dairy Science 78: 2326–2335.
Carminati, D., Giraffa, G., Quiberoni, A., Binetti, A., Suarez, V. dan Reinheimer, J. (2010).
Advances and trends in starter cultures for dairy fermentation. Ed. F. Mozzi, R. Raya, and G. M. Vignolo. Dalam: Biotechnology of Lactic Bacteria. 177–192. Willey-Blackwell, Iowa.
Dalie, D.K.D., Deschamps, A.M. dan Richard-Forget, F. (2010). Lactic acid bacteria potential for control of mould growth and mycotoxin. Food Control 21: 370–380.
Gunaratne, A. dan Corke, H. (2007). Influence of prior acid treatment on acetylation of wheat, potato, and maize starch. Food Chemistry 105: 917–925.
Guyot, J.P. dan Morlon-Guyot, J. (2001). Effect of different cultivation condition on Lactobacillus manihotivorans OND32T, an amylolytic lactobacillus isolated from cassava sour starch. International Journal of Food Microbiologi 67: 217–225.
Hodidjah, S. (2012). Cara Membuat Tepung Mocaf atau Motekap. Badan Pelaksana Penyuluhan Pertanian Perikanan dan Kehutanan (BP4K) Kabupaten Bogor. www.bp4k.bogorkab.go.id. [2 Mei 2012].
Huch, M., Hanak, A., Specht, I., Dortu, C.M., Thonart, P., Mbugua, S., Holzapfel, C. dan Franz, C.M.A.P. (2008). Use of Lactobacillus strain to start cassava fermentations for Garri production. International Journal of Food Microbiology 128: 258–267.
Kurniati, L.L., Aida, N., Gunawan, S. dan Widjaja, T. (2012). Pembuatan mocaf (modified cassava flour) dengan proses fermentasi menggunakan Lactobacillus plantarum, Saccharomyces cerevisae dan Rhizopus oryzae. Jurnal Teknik POMITS 1(1): 1–6.
Kurtman, L., Charlote, U.C., Jeins, R. dan Leis, H.S. (2009). Storage stabillity of freeze-dried Lactobacillus acidophillus (La-5) in relation to water activity and precence of oxygen and ascorbate. Cryobiology 58: 175–180.
Lacerda, I.C.A., Miranda, R.L., Borelli, B.M., Nunes, A.C., Nardi, R.M.D., Lachance, M.A. dan Rosa, C.A. (2005). Lactic acid bacteria and yeasts assosiated with spontaneous fermentations during the production of sour cassava starch in Brazil. International Journal of Food Microbiology 105: 213–219.
Papagianni, M. (2012). Metabolyc Engineering of lactic acid bacteria for the production on industrially important compound. Computational and Structural Biotechnology Journal 3(4): 1–8.
Phumkhachorn, P. dan Rattanachaikunsopon, P. (2010). Lactic acid bacteria: their antimicrobial compounds and their uses in food production. Annals of Biological Research 1(4): 218–228.
Putri, W.D.R., Haryadi, Marseno, D.W. dan Cahyanto, M.N. (2011). Effect of biodegradation by lactic acid bacteria on physical properties of cassava starch. International Food Research Journal 18(3): 1149–1154.
Rahayu, E.S. (1996). Lactic acid bacteria in fermented food of indonesia origin. Agritech 23(2): 75–84.
Rahayu, E.S., Djaffar, T.F., Wibowo, D. dan Sudarmadji, S. (1996). Lactic acid bacteria from indigenous fermented food and their antimicrobial activity. Journal Indonesian Food and Nutrition Progress 3(2): 21–27.
Reddy, G.M., Altaf, B.J. Naveena, M. Venkateshwar, E. dan Kumar, V. (2008). Amylolytic bacterial lactic acid fermentation, a review. Biotechnology Advances 26: 22–34.
Sobowale, A.O., Olurin, T.O. dan Oyewole, O.B. (2007). Effect of lactid acid bacteria starter culture fermentation of cassava on chemical and sensory characteristic of “fufu” flour. African Journal of Biotechnology 6(16): 1954–1958.
Tetchi, F.A. (2012). Effect of cassava variety and fermentation time on biochemical and microbiological characteristics of raw artisanal starter for “attieke” production. Innovative Romanian Food Biotechnology 10: 40–47.
Widiatmi, N. (2013). Profil Fermentasi Hancuran Kasava Menggunakan Starter Basah Bakteri Lactobacillus Plantarum UA3 dengan Bahan Pembawa Hancuran Kasava. Tesis. Fakultas Teknologi Pertanian. Universitas Gadjah Mada, Yogyakarta.
DOI: https://doi.org/10.22146/agritech.18821
Article Metrics
Abstract views : 6580
| 
views : 33473
Refbacks
- There are currently no refbacks.
Copyright (c) 2017 Zulafa Noor, Muhammad Nur Cahyanto, Retno Indrati, Sardjono Sardjono
This work is licensed under a Creative Commons Attribution-ShareAlike 4.0 International License.
agriTECH has been Indexed by:
agriTECH (print ISSN 0216-0455; online ISSN 2527-3825) is published by Faculty of Agricultural Technology, Universitas Gadjah Mada in colaboration with Indonesian Association of Food Technologies.