* Corresponding Author
Karakteristik Fisikokimia Gelatin Tulang Ikan Patin (Pangasius sutchi) Hasil Ekstraksi Menggunakan Limbah Buah Nanas (Ananas comosus)
https://doi.org/10.22146/agritech.29821 Yoni Atma(1), Hisworo Ramdhani(2*), Apon Zaenal Mustopa(3), Mega Pertiwi(4), Rizkia Maisarah(5)
(1) Program Studi Ilmu dan Teknologi Pangan, Fakultas Bioindustri, Universitas Trilogi, Jl. TMP. Kalibata No.1, Kalibata, Jakarta Selatan 12760
(2) Program Studi Ilmu dan Teknologi Pangan, Fakultas Bioindustri, Universitas Trilogi, Jl. TMP. Kalibata No.1, Kalibata, Jakarta Selatan 12760
(3) Pusat Penelitian Bioteknologi, Lembaga Ilmu Pengetahuan Indonesia (LIPI), Jl. Bogor Km. 46, Cibinong 16911
(4) Program Studi Ilmu dan Teknologi Pangan, Fakultas Bioindustri, Universitas Trilogi, Jl. TMP. Kalibata No.1, Kalibata, Jakarta Selatan 12760
(5) Program Studi Ilmu dan Teknologi Pangan, Fakultas Bioindustri, Universitas Trilogi, Jl. TMP. Kalibata No.1, Kalibata, Jakarta Selatan 12760
(*) Corresponding Author
Abstract
Fish bones are the most potential as an alternative source for gelatin production. Pangasius catfish bone is the one of the most promising source due to its high yield of gelatin. It has similar gel strength with the commercial gelatin and has a low ash content. The aim of this research was to determine the physical and chemical characteristics of Pangasius catfish bone gelatin extracted using pineapple waste. Pineapple waste has a low pH and contains citric acid. The research was conducted in two stages i.e. gelatin extraction and physicochemical characterization. Gelatin extraction was done by pre-treatment and main extraction. Pre-treatment was done by soaking the fish bone into pineapple waste for 32, 48, and 56 hours. The main extraction was carried out by soaking fish ossein in warm water for 5 hours at 75 °C. The sodium dodecyl sulfate polyacrylamide gel electrophoresis (SDS-PAGE) was used to analyze the gelatin existence. Fish bone gelatin has molecular weight ranging from 100-150 kDa and > 225 kDa. The hydroxyproline content of gelatin was 10.9–16.3 mg/g. Gelatin of Pangasius catfish bone extracted with pineapple waste has gel strength of 64.83 g.bloom g, hardness of 4.96 N, cohesiveness of 0.88, springiness of 1.03 mm, gumminess of 4.36 N, and chewiness of 2.78 N. Viscosity and pH of gelatin solution obtained were 3.17 cP and 4.52 respectively. The proximate characteristics obtained were moisture 8.59%, ash 0.95%, crude protein 47.60% and fat 7.71%. Some physicochemical parameters of gelatin resemble commercial gelatin and other fish bone gelatin.
ABSTRAK
Tulang ikan merupakan salah satu sumber alternatif untuk produksi gelatin yang sangat potensial. Gelatin dari tulang ikan patin yang diekstrak dengan asam diketahui memiliki hasil ekstraksi yang tertinggi, kekuatan gel yang menyerupai gelatin komersial dan kadar abu yang rendah. Penelitian ini dilakukan untuk mengetahui karakteristik fisik dan kimiawi gelatin tulang ikan patin yang diekstrak dengan limbah buah nanas. Limbah buah nanas diketahui mengandung asam sitrat cukup tinggi. Penelitian dilakukan dengan dua tahap yakni ekstraksi gelatin dan analisis karakteristik fisikokimianya. Ekstraksi gelatin dilakukan dengan dua tahap yakni pre-treatment dan ekstraksi utama. Pre-treatment dilakukan dengan perendaman tulang ikan dalam limbah buah nanas selama 32, 48, dan 56 jam. Ekstraksi utama dilakukan dengan perendaman dalam air hangat selama 5 jam suhu 75 °C. Analisis keberadaan gelatin dengan metode SDS-PAGE diketahui gelatin berada pada kisaran berat molekul 100–150 kDa dan > 225 kDa. Kadar hidroksiprolin gelatin yakni 10,9–16,3 mg/g. Gelatin tulang ikan patin yang diekstrak dengan limbah buah nanas memiliki kekuatan gel 64,83 g.bloom, kekerasan (hardness) 4,96 g, kohesivitas (cohesiveness) 0,88, elastisitas (springiness) 1,03, kekenyalan (gumminess) 4,36, daya kunyah (chewiness) 2,78. Viskositas dan pH larutan gelatin yang diperoleh masing-masing 3,17 cP dan 4,52. Karakteristik kimiawi gelatin yang diperoleh antara lain meliputi kadar air 8,59%, abu 0,95%, protein kasar 47,60% dan lemak 7,71%. Beberapa karakteristik fisikokimia gelatin tulang ikan pada penelitian ini dapat dibandingkan dengan gelatin komersial dan gelatin tulang ikan yang lain.
Keywords
Full Text:
PDF (Bahasa Indonesia)References
Abdullah & Mat, H. (2017). The Characteristic of pineapple waste from canning industry. Advanced Science Letters, 23(6), 5691–5693.
Abdullah, A., & Mat, H. (2008). Characterisation of Solid and Liquid Pineapple Waste. Reaktor, 12(1), 48–52. http://doi.org/10.14710/reaktor.12.1.48-52.
Ahmad, M., & Benjakul, S. (2011). Characteristics of gelatin from the skin of unicorn leatherjacket (Aluterus monoceros) as influenced by acid pretreatment and extraction time. Food Hydrocolloids, 25(3), 381–388. http://doi.org/10.1016/j.foodhyd.2010.07.004.
Amiza, M. A., Wan Maizatul Shima, W. M., Nor Hayati, I., & Nizaha Juhaida, M. (2015). Optimization of gelatin extraction conditions from Cobia (Rachycentron canadum) skin and its physicochemical characteristics as compared to bovine gelatin. International Food Research Journal, 22(1), 213–224.
Atma, Y. (2017). Amino acid and proximate composition of fish bone gelatin from different warm-water species : A comparative study. IOP Conf. Ser.: Earth Environ. Sci., 58(012008), 6–11. http://doi.org/10.1088/1755-1315/5.
Badii, F., & Howell, N. K. (2006). Fish gelatin: Structure, gelling properties and interaction with egg albumen proteins. Food Hydrocolloids, 20(5), 630–640. http://doi.org/10.1016/j.foodhyd.2005.06.006.
Bergman, I., & Loxley, R. (1963). Two Improved and Simplified Methods for the Spectrophotometric Determination of Hydroxyproline. Analytical Chemistry, 35(12), 1961–1965. http://doi.org/10.1021/ac60205a053.
Bhale, S. D. (2004). Effect of Ohmic Heating on Color, Rehydration and Textural Characteristics of Fresh Carrot Cubes [thesis]. Department of Biological & Agricultural Engineering, B.Tech, Mahatma Phule Agricultural University, India.
Chandra, M. V., & Shamasundar, B. A. (2015). Texture profile analysis and functional properties of gelatin from the skin of three species of fresh water fish. International Journal of Food Properties, 18(3), 572–584. http://doi.org/10.1080/10942912.2013.845787.
Da Trindade Alfaro, A., Simões Da Costa, C., Graciano Fonseca, G., & Prentice, C. (2009). Effect of extraction parameters on the properties of gelatin from king weakfish (Macrodon ancylodon) Bones. Food Science and Technology International, 15(6), 553–562. http://doi.org/10.1177/1082013209352921.
Fatimah, D., Jannah, A. (2009). Efektivitas Penggunaan Asam Sitrat Dalam Pembuatan Gelatin Tulang Ikan Bandeng (Chanos-Chanos Forskal). Alchemy, 1 (1): 7-15
GMIA. (2013). Standard testing methods for edible gelatin, (July), 27. http://doi.org/10.1021/ja02055a023.
Gomez-Guillen, M. C., Gimenez, B., Lopez-Caballero, M. E., & Montero, M. P. (2011). Functional and bioactive properties of collagen and gelatin from alternative sources: A review. Food Hydrocolloids, 25(8), 1813–1827. http://doi.org/10.1016/j.foodhyd.2011.02.007.
Hafidz, R., & Yaakob, C. (2011). Chemical and functional properties of bovine and porcine skin gelatin. International Food Research Journal, 817, 813–817.
Hajar, N., Zainal, S., Nadzirah, K. Z., Roha, A. M. S., Atikah, O., & Elida, T. Z. M. T. (2012). Physicochemical Properties Analysis of Three Indexes Pineapple (Ananas Comosus) Peel Extract Variety N36. APCBEE Procedia, 4, 115–121. http://doi.org/10.1016/j.apcbee.2012.11.020.
Jeya Shakila, R., Jeevithan, E., Varatharajakumar, A., Jeyasekaran, G., & Sukumar, D. (2012). Functional characterization of gelatin extracted from bones of red snapper and grouper in comparison with mammalian gelatin. LWT - Food Science and Technology, 48(1), 30–36. http://doi.org/10.1016/j.lwt.2012.03.007.
Karayannakidis, P. D., & Zotos, A. (2016). Fish Processing By-Products as a Potential Source of Gelatin: A Review. Journal of Aquatic Food Product Technology, 25(1), 65–92. http://doi.org/10.1080/10498850.2013.827767.
Karim, A. A., & Bhat, R. (2009). Fish gelatin: properties, challenges, and prospects as an alternative to mammalian gelatins. Food Hydrocolloids, 23(3), 563–576. http://doi.org/10.1016/j.foodhyd.2008.07.002.
Ketnawa, S., Chaiwut, P., & Rawdkuen, S. (2012). Pineapple wastes: A potential source for bromelain extraction. Food and Bioproducts Processing, 90(3), 385–391. http://doi.org/10.1016/j.fbp.2011.12.006.
Khiari, Z., Rico, D., Martin-Diana, A. B., & Barry-Ryan, C. (2011). The extraction of gelatine from mackerel (Scomber scombrus) heads with the use of different organic acids. Journal of FisheriesSciences.Com, 5(1), 52–63. http://doi.org/10.3153/jfscom.2011007.
KKP. (2016). Performance Report of the Ministry of Marine Affairs and Fisheries Year 2015. Kementerian Kelautan Dan Perikanan, 1–57.
Koli, J. M., Basu, S., Nayak, B. B., Patange, S. B., Pagarkar, A. U., & Gudipati, V. (2012). Functional characteristics of gelatin extracted from skin and bone of Tiger-toothed croaker (Otolithes ruber) and Pink perch (Nemipterus japonicus). Food and Bioproducts Processing, 90(3), 555–562. http://doi.org/10.1016/j.fbp.2011.08.001.
Liu, H. Y., Han, J., & Guo, S. D. (2009). Characteristics of the gelatin extracted from Channel Catfish (Ictalurus Punctatus) head bones. LWT - Food Science and Technology, 42(2), 540–544. http://doi.org/10.1016/j.lwt.2008.07.013.
Mahmoodani, F., Ardekani, V. S., See, S. F., Yusop, S. M., & Babji, A. S. (2014). Optimization and physical properties of gelatin extracted from pangasius catfish (Pangasius sutchi) bone. Journal of Food Science and Technology, 51(11), 3104–3113. http://doi.org/10.1007/s13197-012-0816-7.
Mariod, A. A., & Adam, H. F. (2013). Review: Gelatin, source, extraction and industrial applications. Acta Scientiarum Polonorum, Technologia Alimentaria, 12(2), 135–147. http://doi.org/10.1002/adma.200802244.
Mariod A.A., Abdel-Wahab S.I., Ibrahim M.Y., M. S., & Abd Elgadir M., A. N. M. (2011). Preparation and Characterization of Gelatins from Two Sudanese Edible Insects Preparation and Characterization of Gelatins from Two Sudanese Edible Insects. J. Food Sci. Eng., 1(September 2015), 45–55.
Muyonga, J. H., Cole, C. G. B., & Duodu, K. G. (2004). Extraction and physico-chemical characterisation of Nile perch (Lates niloticus) skin and bone gelatin. Food Hydrocolloids, 18(4), 581–592. http://doi.org/10.1016/j.foodhyd.2003.08.009.
Nurul, A. G., & Sarbon, N. M. (2015). Effects of pH on functional, rheological and structural properties of eel (Monopterus sp.) skin gelatin compared to bovine gelatin. International Food Research Journal, 22(2), 572–583.
Rahman, M. S., & Al-Mahrouqi, A. I. (2009). Instrumental texture profile analysis of gelatin gel extracted from grouper skin and commercial (bovine and porcine) gelatin gels. International Journal of Food Sciences and Nutrition, 60(SUPPL. 7), 229–242. http://doi.org/10.1080/09637480902984414.
Ratnasari, I., Yuwono, S. S., Nusyam, H., & Widjanarko, S. B. (2013). Extraction and characterization of gelatin from different fresh water fishes as alternative sources of gelatin. International Food Research Journal, 20(6), 3085–3091.
Sanaei, A. V., Mahmoodani, F., See, S. F., Yusop, S. M., & Babji, A. S. (2013). Optimization of gelatin extraction and physico-chemical properties of catfish (Clarias gariepinus) bone gelatin. International Food Research Journal, 20(1), 423–430.
Shyni, K., Hema, G. S., Ninan, G., Mathew, S., Joshy, C. G., & Lakshmanan, P. T. (2014). Isolation and characterization of gelatin from the skins of skipjack tuna (katsuwonus pelamis), dog shark (scoliodon sorrakowah), and rohu (labeo rohita). Food Hydrocolloids, 39, 68–76. http://doi.org/10.1016/j.foodhyd.2013.12.008.
Taheri, A., Abedian Kenari, A. M., Gildberg, A., & Behnam, S. (2009). Extraction and physicochemical characterization of greater lizardfish (Saurida tumbil) skin and bone gelatin. Journal of Food Science, 74(3), 160–165. http://doi.org/10.1111/j.1750-3841.2009.01106.x.
Wang, Y., & Regenstein, J. M. (2009). Effect of EDTA, HCl, and citric acid on Ca salt removal from Asian (silver) carp scales prior to gelatin extraction. Journal of Food Science, 74(6), 426–431. http://doi.org/10.1111/j.1750-3841.2009.01202.x.
Wangtueai, S., & Noomhorm, A. (2009). Processing optimization and characterization of gelatin from lizardfish (Saurida spp.) scales. LWT - Food Science and Technology, 42(4), 825–834. http://doi.org/10.1016/j.lwt.2008.11.014.
Zhang, F., Xu, S., & Wang, Z. (2011). Pre-treatment optimization and properties of gelatin from freshwater fish scales. Food and Bioproducts Processing, 89(3), 185–193. http://doi.org/10.1016/j.fbp.2010.05.003.
DOI: https://doi.org/10.22146/agritech.29821
Article Metrics
Abstract views : 7794
| 
views : 8028
Refbacks
- There are currently no refbacks.
Copyright (c) 2018 Yoni Atma, Hisworo Ramdhani, Apon Zaenal Mustopa, Mega Pertiwi, Rizkia Maisarah
This work is licensed under a Creative Commons Attribution-ShareAlike 4.0 International License.
agriTECH has been Indexed by:
agriTECH (print ISSN 0216-0455; online ISSN 2527-3825) is published by Faculty of Agricultural Technology, Universitas Gadjah Mada in colaboration with Indonesian Association of Food Technologies.